Product ID:RED TONER, 887405, FT 5000/5010
MSDS Date:03/25/1992
FSC:6850
NIIN:00N065138
MSDS Number: BZKZT

RICOH CORP

5 DEDRICK PLACE
WEST CALDWELL, NJ 07006
US

Emergency Phone: 800-336-6737

Info Phone: 201-882-2000; 800-336-6737

Preparer: KRISTINA SAGE

Cage: RICOH

RICOH CORPORATION

WEST CALDWELL, NJ 07006-6304 US

Telephone: 800-336-6737

Cage: 54726

STYRENE ACRYLIC RESIN; (STYRENE ACRYLIC POLYMER)

CAS: 26655-10-7

Fraction By Weight: 91%

OSHA PEL N/K

ACGIH TLV: N/K

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 6%

OSHA PEL N/K

ACGIH TLV: N/K

AROMATIC METAL SALT; (ORGANIC SALT)

CAS: 42405-40-3

Fraction By Weight: 3%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50:(ORAL) >5 G/KG BODYWEIGHT.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE/INHAL:NOT APPLICABLE.
SKIN(RABBIT): NON-IRRITANT. CHRONIC:IN A XEROX SPONSORED CHRONIC
INHAL STUDY IN RATS USINA A SPECIAL TEST TONER, A VERY SLIGHT
DEGREE OF FIBROSIS WAS NOTED IN 25% OF AN IMALS AT MIDDLE EXPOS
LEVEL (4 MG/M3) WHILE A SLIGHT DEGREE OF FIBROSIS WAS OBSERVED AT
HIGHEST EXPOS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:LEVEL (16 MG/M3) IN ALL ANIMALS. THESE
FINDINGS ARE ATTRIBUTED TO "LUNG OVERLOADING", A GENERIC RESPONSE
TO EXCESSIVE AMTS OF ANY DUST RETAINED IN LUNGS FOR PRLNG INTERVAL.
THE SPECIAL TEST T ONER WAS TEN TIMES MORE RESPIRABLE
THANCOMMERCIALLY AVAIL TONER TO COMPLY W/EPA TESTING PROTOCOL &
WOULD NOT (SUPDAT)
Medical Cond Aggravated by Exposure:WILL NOT OCCUR.

First Aid:EYES:TRY TO REMOVE OR FLUSH OUT W/DROPS FOR AT LEAST 15
MINUTES. IF UNSUCCESSFUL, GET MEDICAL ATTENTION. SKIN:WASH
THOROUGHLY W/SOAP & WATER. INHAL:REMOVE FROM EXPOSURE.
INGEST:DILUTE STOMACH CONTENTS W/SEVERAL GLASSES OF WATER.

Extinguishing Media:FOAM, WATER SPRAY (MIST), DRY CHEMICALS OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NO SPECIAL FIRE-FIGHTING PROCEDURE IS NECESSARY.
Unusual Fire/Explosion Hazard:WILL NOT OCCUR.

Spill Release Procedures:IF SPILLED, SWEEP UP USING APPRVD TONER VACUUM
CLEANER W/0.5 MICRON FILTER SUCH AS ATRIX AAA TONER VACUUM CLEANER
(RICOH EDP CODE 342MIU). USE OF VACUUM NOT RATED FOR TONER
PARTICULATE COULD BE POTNTL FIRE HAZ &/OR RSLT IN PERSONAL
INJURY.(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP OUT
OF REACH OF CHILDREN. MINIMIZE BREATHING DUST.
Other Precautions:DO NOT HANDLE IN AREAS WHERE WIND BLOWS. FLYING
POWDER MAY ENTER EYES. MINIMIZE INHALATION OF DUST.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
Ventilation:LOCAL EXHAUST:NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
MECHANICAL (GENERAL):ADEQUATE VENTILATION.
Protective Gloves:NONE NEEDED UNDER NORMAL CNDTNS OF USE.
Eye Protection:NONE NEEDED UNDER NORMAL CNDTNS OF USE.
Other Protective Equipment:NONE NEEDED UNDER NORMAL CONDITIONS OF USE.
Work Hygienic Practices:CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE
BREAKS & MEALS & AT THE END OF WORK PERIODS.
Supplemental Safety and Health
EFTS OF OVEREXP:FUNCTION PROPERLY IN XEROGRAPHIC EQUIPMENT. SPILL
PROC:REMOVE RESIDUE W/SOAP & WATER. WASTE DISP METH:OF DISPOSAL. DO
NOT INCINERATE.

Spec Gravity:0.34
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:RED POWDER; NO ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Hazardous Decomposition Products:CARBON MONOXIDE & OTHER DECOMPOSITION
PRODUCTS IN THE CASE OF INCOMPLETE COMBUSTION.

Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS . USED
TONER SHOULD BE DISP OF IN ENVIRONMENTALLY SAFE MANNER & I/A/W GOVT
REGS. DISP REGS VARY FROM LOCALITY TO LOCALITY, THEREFORE, CONSULT
YOUR LOC OF FICE OF THE EPA TO DETERMINE PROPER METHOD(SUPDAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.